Volvo V60

The Roots-type supercharger on the T6 Drive-E tends to seal failure from around 150,000–200,000 km. Degraded plastic and rubber parts allow uncontrolled air ingress. Typical fault code: P0171 (system lean). Repair cost 2,000–5,000 €.

Symptoms: Power drop especially at low rpm, check engine light P0171, poor fuel economy, supercharger ancillary noises

The timing belt change on the T6 is more complex than on T4/T5 due to the integrated supercharger. Labour time and costs are correspondingly higher. Change interval 120,000 km/8 years also applies.

Symptoms: No warning signs; recommendation: inspect from 100,000 km

The T6 supercharger bypass valve fails mechanically and triggers fault code ECM P00C423. Typical problem on older T6 engines, causing power loss and irregular engine running.

Symptoms: Irregular power delivery, check engine light with code P00C4, power drop at shift points

The T6 Drive-E shares the oil consumption problem of the early VEP4 family. All T6 pre-production years (2015–2018) are known as 'oil burners'. Volvo warranty extension to 8 years applies to documented cases.

Symptoms: Noticeably dropping oil level, no visible external loss, occasional blue smoke

The five-cylinder diesel D5 is prone to cylinder head cracks and worn cylinder liners, particularly on models built between 2010 and 2013. Coolant loss without a visible leak is the first warning sign.

The 6-speed dual-clutch gearbox 6DCT450 shows juddering on pull-away, rough gear changes and transmission fluid loss. Neglecting fluid changes risks complete transmission failure.

A software fault can cause the electric parking brake on models up to 2014 to release unintentionally. A Volvo recall and software update fix the problem.

A faulty weld between the rotor shaft and the hydraulic brake assembly was found on the V90 II and S90 II. If it fails, ABS, ESC and brake assist are disabled. Volvo issued a recall in 2021.

On XC60 II vehicles built between September 2018 and April 2019, nuts and bolts at the rear axle may be too loose. Handling can change abruptly; check recall status.

Loose flange nuts on the rear toe link can abruptly worsen handling. Check for Volvo recall; affects S60 and V60 from September 2018.

Water gets into the windscreen wiper motor and causes it to fail. SPA platform models are affected; a 2020 recall addressed incorrectly tightened wiper arms. Visibility in rain significantly impaired.

MOT reports criticise above-average wear on tie rod ends, ball joints and suspension bushings at the front axle of the V60 III. This occurs earlier with heavier engine variants or sporty driving.

On the V60 III, the optional panoramic sunroof drainage channels block with leaves and dirt. Backed-up water enters the interior, often under the dashboard or onto the rear seat.