Volvo S60
Drive-E turbocharged four-cylinder with 2.0 litres and 187 kW for the T5 range. Larger turbocharger than the T4 with higher boost pressure for a more sporting character. Eight-speed Aisin automatic as standard; strictly observe oil change intervals.
Powerful long-distance companion
Strong turbo for brisk motorway runs without strain. Typically Volvo: comfort remains the trump card.
Engine Weaknesses 6
All Drive-E T variants use belt drive. On the T5 with high-pressure turbo, the belt change is especially important — a failure causes immediate total engine damage. Recommendation: early change at 100,000 km.
Symptoms: No warning before sudden failure; possible squealing with failing tensioner
The high-output T5 Drive-E shares the piston ring problem with the T4. Vehicles up to MY2016 are particularly affected. Increased oil consumption is systemic and was covered by a class action lawsuit.
Symptoms: Oil consumption above 0.5 L/1,000 km, blue smoke on warm-engine acceleration, oil level drops noticeably between changes
The Drive-E T5 uses a timing belt (not a chain). Volvo's stated change interval is 150,000 miles / 10 years, but specialists recommend considerably earlier (120,000–150,000 km). Belt failure causes engine damage.
Symptoms: No early warning signs typical — sudden engine stop without prior indication at belt failure. Prevention: inspect for cracking at every service
The T5 is among the most frequently affected Drive-E engines for the oil consumption problem. Particularly 2015–2017 model years were addressed under a service campaign (S29650). Volvo extended the warranty to 8 years.
Symptoms: Oil level drops noticeably between changes, occasional blue smoke, no visible external oil loss
The crankcase ventilation of the T5 Drive-E clogs when oil change intervals are neglected. Crankcase pressure forces oil past seals, accelerates oil consumption and can cause turbocharger damage.
Symptoms: Overpressure at oil filler, oil in air filter housing, elevated oil consumption
Rubber boost pipes to the intercooler age and burst under driving conditions. On the T5, more frequent than on the T4 due to higher boost pressures. A short-term repair is often possible, but permanent hose replacement is recommended.
Symptoms: Sudden power loss, whistling or hissing noise, check engine light P0299 (turbo underboost)
Vehicle Weaknesses 9
Loose flange nuts on the rear toe link can abruptly worsen handling. Check for Volvo recall; affects S60 and V60 from September 2018.
MOT reports criticise above-average wear on tie rod ends, ball joints and suspension bushings at the front axle of the S60 III and V60 III. This occurs earlier with heavier engine variants or sporty driving.
On the S60 III and V60 III, the optional panoramic sunroof drainage channels block with leaves and dirt. Backed-up water enters the interior, often under the dashboard or onto the rear seat.
The electric tailgate on the V60 II shows malfunctions from 20,000–40,000 km, fails to close fully or responds with a delay. Known issue on SPA models from model year 2019 onwards.
The rain sensor, parking aid and adaptive lighting on early S60 III/V60 II show software faults. Creaks and clicks from the dashboard and door trims are also widespread.
Rear brake pads wear faster than the fronts on the S60 III and V60 II. Electric parking brake and automatic braking functions accelerate the wear further.
The interior trim on the S60 III (and V60 III) is considered insufficiently heat-stable. Temperature fluctuations create annoying clicks and creaks in the door trims, dashboard and seat area.
Software updates for the S60 III can resolve existing issues with the rain sensor, parking aid, power steering support or adaptive lighting, but sometimes introduce new faults. Volvo has not yet fully mastered the electronics.
MOT reports show above-average brake disc wear on the S60 III/V60 III. On plug-in hybrids in particular, rarely used brake discs corrode quickly due to predominant use of regenerative braking.
Reports & Tests
4 owner complaints filed with NHTSA (2018–2024). Most reported: Other (1), Electrical (1), Engine (1).