Volvo S60
EcoBoost turbocharged four-cylinder with 1.6 litres, developed in the Volvo-Ford partnership and manufactured in Wales. Direct injection with turbocharging for good torque at low fuel consumption. Note thermal stress on the turbocharger during spirited driving.
Sport design, no sport heart
The S60 looks like a sports car — the 1.6T acts like one. Almost convincing.
Engine Weaknesses 4
The Ford-derived 1.6 EcoBoost (B4164T) had a defective head gasket with incomplete die-cut holes that restricted coolant flow. Overheating without warning possible due to missing coolant level sensor — led to a recall.
Symptoms: Sudden coolant loss without warning, engine temperature rises quickly, coolant smell
Ford recalled in 2014 vehicles with the 1.6-litre EcoBoost because the cylinder head could overheat and catch fire if coolant was lost. Fix: retrofit of a coolant level sensor and software update.
On the Ford-derived EcoBoost engine of the B4164T, coolant hoses at the turbo crack under thermal and pressure cycling. Coolant loss under load is possible and can lead to overheating.
Symptoms: Coolant loss after motorway driving, white steam from engine bay, rising coolant temperature
The Powershift DSG combination with the B4164T was known for jerky gear changes. Problems including transmission damage were reported, especially on early model years (up to 2015).
Symptoms: Jerking on pull-away, empty gearbox feel, shift hesitation in the lower rpm range
Vehicle Weaknesses 11
The five-cylinder diesel D5 is prone to cylinder head cracks and worn cylinder liners, particularly on models built between 2010 and 2013. Coolant loss without a visible leak is the first warning sign.
The 6-speed dual-clutch gearbox 6DCT450 shows juddering on pull-away, rough gear changes and transmission fluid loss. Neglecting fluid changes risks complete transmission failure.
A software fault can cause the electric parking brake on models up to 2014 to release unintentionally. A Volvo recall and software update fix the problem.
A faulty weld between the rotor shaft and the hydraulic brake assembly was found on the V90 II and S90 II. If it fails, ABS, ESC and brake assist are disabled. Volvo issued a recall in 2021.
On XC60 II vehicles built between September 2018 and April 2019, nuts and bolts at the rear axle may be too loose. Handling can change abruptly; check recall status.
Water gets into the windscreen wiper motor and causes it to fail. SPA platform models are affected; a 2020 recall addressed incorrectly tightened wiper arms. Visibility in rain significantly impaired.
At higher mileages, worn tie rod ends, ball joints and suspension bushings on the S60 II/V60 I are frequently flagged by MOT inspectors. Tyre wear is very sensitive on this vehicle.
The audio and navigation system in the S60 II/V60 I fails due to cold solder joints on the control unit board — a known issue across this Volvo model generation. Replacement units cost over €700.
The Sensus infotainment system on the SPA platform (XC60 II, S90 II, V90 II, S60 III, V60 II) freezes or reboots while driving. Software updates improve stability. Steering wheel controls drop out sporadically.
The optional panoramic roof on the V90 II and S90 II shows malfunctions when opening/closing automatically. Faulty sensors or motor controllers can be expensive; water ingress possible if the seal is damaged.
The BLIS blind spot sensor on the S60 II/V60 I reacts to moisture ingress in the wiring harness with false alarms or complete system failure. Recalibration or sensor replacement is required.
Reports & Tests
333 owner complaints filed with NHTSA (2010–2018). Most reported: Engine (138), Other (50), Electrical (41).