Dodge Durango WD

FCA's workhorse V6, 305 hp, DOHC 24-valve — same Pentastar in half the Stellantis lineup. No MDS, no lifter lottery. Rocker arm tick around 60k miles. Plastic oil filter housing cracks — Dorman 926-959 metal replacement is the permanent fix. A small sleeper community runs ProCharger ($6,349) or RIPP ($6,799) kits pushing 400-450 whp on stock internals, bolt-on. Whether $12k all-in on a boosted V6 beats buying a used R/T is the question nobody agrees on.

• !! Rocker arm tick from 150,000 km

  Rocker arm develops audible tick from worn contact surfaces, typically after 60,000 miles. Parts cheap ($50-80 per arm), labor drives cost due to intake manifold removal.

  Symptoms: Ticking from upper engine, louder when cold, doesn't disappear after warmup
  500–1,800 $
  Ad 5184296AH rocker arm Pentastar 3.6rocker arm Pentastar Challenger
• !! Oil filter housing leak — plastic cracks from 210,000 km

  Plastic oil filter housing becomes brittle, develops cracks. Oil and coolant passages run through the housing — cross-contamination possible. Dorman 926-959 metal replacement is the permanent fix.

  Symptoms: Oil drip under engine, low oil warning, milky residue on oil cap in severe cases
  200–700 $
  Ad 68105583AF oil filter housing PentastarDorman 926-959 oil filter housing
• !! Timing chain tensioner stretch (2011-2013) from 310,000 km

  Timing chain tensioner loses tension from chain stretch, primarily 2011-2013 units. Cold start rattle, can jump timing in extreme cases.

  Symptoms: Rattle on cold start from front of engine, check engine light for cam/crank correlation
  600–1,500 $
  Ad 5184357AE timing chain tensioner Pentastartiming chain kit 3.6 Pentastar

5.7L Hemi V8, cast iron block, pushrod two-valve — 375 hp and that unmistakable idle burble. MDS deactivates cylinders 1, 4, 6, 7 under light throttle — deactivated lifters run dry on cam lobes, metal debris destroys the camshaft. Class action: Petro v. FCA. Manual cars skip MDS entirely — no deactivation hardware, no lifter lottery. That is THE buying tip. Software delete via DiabloSport/HP Tuners: $400-650, prevents activation but lifters stay, voids warranty, costs 2-4 MPG. On 0W-40 at 5,000 mile intervals, the bottom end is solid.

• !! MDS lifter failure — camshaft destruction from 160,000 km

  MDS deactivates 4 cylinders under light load. Deactivated lifter rollers run dry, metal debris destroys camshaft. Class action: Petro v. FCA (1:22-cv-00621). Engine replacement ~$5,000. Manual cars have NO MDS — this failure doesn't apply to stick-shift Challengers.

  Symptoms: Loud ticking progressing to knocking, misfires, check engine light, metal shavings in oil
  1,500–5,000 $
  Ad MDS lifter 5.7 Hemi Challenger5038785AD lifter yokeMDS delete kit 5.7 Hemi
• !! Water pump failure from 160,000 km

  Plastic impeller separates or bearing wears. Weep hole dripping coolant is the early warning. Bearing failure causes pulley wobble.

  Symptoms: Coolant puddle under front, squealing noise, overheating, pulley wobble
  400–1,200 $
  Ad 53022091AA water pump 5.7 Hemiwater pump Challenger R/T
• ! Hemi tick — harmless or catastrophic from 75,000 km

  Metallic ticking from valvetrain on cold start. Can be harmless exhaust manifold leak or dangerous MDS lifter damage. Tick that persists past warmup is a red flag for lifter failure.

  Symptoms: Ticking on cold start, may disappear after warmup (exhaust) or persist and worsen (lifter)
  0–500 $
  Ad 5038785AD lifter yoke 5.7 Hemi53021726AE lifter bridge Hemi MDS

+ 1 more engine weaknesses + vehicle weaknesses

392 cubic inches, 4.09-inch bore, 485 hp — the biggest factory NA V8 of the 2020s. Forged steel crankshaft where the 5.7 uses cast iron — the real upgrade. Powder metal rods, cracked-cap design. Pistons are hypereutectic, not forged — ring lands too thin for boost, supercharger kits crack them. Same MDS lifter failure on automatics — engine replacement $15,000. Manual 392s skip MDS. VVT and active intake give 45 lb-ft more than the old 6.1 SRT. On 0W-40 at 5k intervals, the rotating assembly outlasts the car.

• !! MDS lifter failure — $15,000 engine replacement from 120,000 km

  Same MDS failure as the 5.7 but with higher stakes. Deactivated rollers destroy camshaft, metal contaminates oil. Engine replacement $4,800-15,000 — replacements can fail the same way. Class action: Petro v. FCA. Manual 392s have NO MDS.

  Symptoms: Progressive ticking to knocking, misfires, check engine light, metal in oil
  4,800–15,000 $
  Ad MDS lifter 6.4 Hemi 39253021726AE lifter 6.4LMDS delete kit 6.4 392
• !! Piston failure under forced induction (modified only)

  Stock cast pistons not designed for boost. Ring land too close to crown, ring gap too wide. Supercharger or turbo kits crack pistons. Forged internals required before adding boost. Only affects modified engines.

  Symptoms: Misfires under boost, loss of compression, knocking, catastrophic failure
  3,000–12,000 $
  Ad forged pistons 6.4 Hemi 392Mahle forged piston 392
• ! Exhaust manifold stud breakage from 210,000 km

  Cast-iron manifold on aluminum head — thermal expansion mismatch breaks studs. Grade 8 replacement studs (6509863AA) are the fix.

  Symptoms: Ticking on cold start from exhaust leak, disappears as metal expands
  400–1,600 $
  Ad 6509863AA manifold stud Hemi 6.4ProMAXX 6.4 Hemi bolt repair

+ 1 more engine weaknesses + vehicle weaknesses

6.2L supercharged V8, IHI twin-screw — 2.4L on standard Hellcat (11.6 PSI, 707-717 hp), 2.7L on Redeye (14.5 PSI, 797 hp, Demon-derived, forged rods + pistons). Black key fob = 500 hp via drive-by-wire throttle mapping. Red fob = everything. SRT Power Chiller diverts A/C refrigerant to cool intake. 2015-2016: snout bolt backs out, destroys bearings — $10-12k. Intercooler bricks leak coolant into cylinders. Heat soak costs 30-50 hp after repeated pulls — physics, not a defect.

• !! Intercooler leak — coolant in cylinders from 13,000 km

  Internal coolant passages in intercooler brick leak into intake. Coolant enters cylinders, causes cold-start misfires, scores cylinder walls. FCA replaces entire supercharger assembly under warranty (~$11,000).

  Symptoms: Misfire on cold start, coolant level drops with no visible leak, white exhaust smoke
  0–11,000 $
  Ad 68417685AA intercooler brick Hellcatsupercharger assembly 6.2 Hellcat
• !! Supercharger snout bearing failure (2015-2017) from 130,000 km

  Early IHI superchargers had bolt backing out, destroying rotor bearings. Supercharger replacement $10-12k. 2017+ improved. Whine at idle is early warning.

  Symptoms: Abnormal whining at idle, boost loss, metal debris in supercharger oil
  800–12,000 $
  Ad IHI supercharger Hellcat 6.2snout bearing Hellcat supercharger
• !! Heat soak — power reduction after hard pulls

  Intake temps above 170F trigger timing retard. After repeated full-throttle passes, 30-50 hp loss until system cools. Physics, not a defect. Interchiller mods help for track use.

  Symptoms: Power drop after multiple full-throttle runs, slow recovery between pulls
  0–2,000 $
  Ad interchiller Hellcat Challengerintercooler upgrade Hellcat 6.2