Volvo V70
Ford four-cylinder turbodiesel with 1.6 litres marketed as the Volvo DRIVe version. SOHC with timing belt and Euro 5 standard. Very economical; conceived for high-mileage drivers with an efficiency focus.
Too little for the big estate
95 hp diesel in the V70 — brave but overwhelmed. City runs and flat motorway stretches only.
Engine Weaknesses 4
The original 240,000 km (150,000-mile) replacement interval of the PSA-derived DV6 was reduced to 140,000 km (87,500 miles) in 2014. Older vehicles maintained on the original interval carry elevated risk.
Symptoms: Sudden engine failure without warning, engine damage on belt snap
The D4162T engine block can crack during overheating events (e.g. from untreated coolant loss). Reports of cracked blocks following coolant starvation are documented in English-language Volvo forums.
Symptoms: Coolant loss following overheating, engine noises, white smoke, engine oil in coolant
The DPF of the PSA DV6/D4162T requires motorway runs for regeneration. With predominantly urban use the filter clogs quickly. An interrupted regeneration cycle (e.g. from engine stall) accelerates clogging.
Symptoms: DPF warning light early after purchase, power reduction, increased fuel consumption, soot smell when parking
On the PSA-derived DV6 diesel, the injector copper seals at the cylinder head interface tend to leak. Cylinder 3 is statistically the most commonly affected; exhaust residues seep out along the outside of the injector.
Symptoms: Soot deposits on outside of injectors, rough running, poor cold-start behaviour
Vehicle Weaknesses 8
The steering rack of the V70 III and S80 II develops leaks and increasing play at high mileages. A faulty steering rack costs around €2,000 to repair.
The front subframe on the V70 III and XC70 II frequently shows corrosion, which, if left untreated, affects the entire front axle assembly. On the XC70 II, the rear subframe also rusts on vehicles built before 2010.
The optional electronic self-levelling suspension on the V70 III XC models fails. Compressor or air springs need replacement; costs up to €1,600 with original Volvo parts.
The tailgate wiring harness breaks at the left hinge arc through metal fatigue. Particularly affected are the rear window heating element, brake lights, wiper and central locking. Typical and very common problem on the V70 III and XC70 II.
The rear control arm rubber bushings on the V70 III and XC70 II typically wear from 160,000–170,000 km and cause driving noises. Also a known issue on the S80 II. Replacement is essential for precise handling.
The audio and navigation system of the V70 III and S80 II fails due to cold solder joints in the control unit. Parking sensors fail at around 170,000 km. Xenon headlights burn out between 170,000 and 200,000 km.
The BLIS blind spot warning system fails due to moisture in the wiring harness or faults in the wing mirror sensors. The warning system remains permanently active or stops responding.
The leather and T-Tec upholstery on the V70 III and S80 II tends to crack and split at the seat bolsters of the driver's seat. This often begins at medium mileages.
Reports & Tests
30 owner complaints filed with NHTSA (2007–2016). Most reported: Electrical (8), Engine (6), Tires (3).