Volvo V60

All Drive-E T variants use belt drive. On the T5 with high-pressure turbo, the belt change is especially important — a failure causes immediate total engine damage. Recommendation: early change at 100,000 km.

Symptoms: No warning before sudden failure; possible squealing with failing tensioner

The high-output T5 Drive-E shares the piston ring problem with the T4. Vehicles up to MY2016 are particularly affected. Increased oil consumption is systemic and was covered by a class action lawsuit.

Symptoms: Oil consumption above 0.5 L/1,000 km, blue smoke on warm-engine acceleration, oil level drops noticeably between changes

The Drive-E T5 uses a timing belt (not a chain). Volvo's stated change interval is 150,000 miles / 10 years, but specialists recommend considerably earlier (120,000–150,000 km). Belt failure causes engine damage.

Symptoms: No early warning signs typical — sudden engine stop without prior indication at belt failure. Prevention: inspect for cracking at every service

The T5 is among the most frequently affected Drive-E engines for the oil consumption problem. Particularly 2015–2017 model years were addressed under a service campaign (S29650). Volvo extended the warranty to 8 years.

Symptoms: Oil level drops noticeably between changes, occasional blue smoke, no visible external oil loss

The crankcase ventilation of the T5 Drive-E clogs when oil change intervals are neglected. Crankcase pressure forces oil past seals, accelerates oil consumption and can cause turbocharger damage.

Symptoms: Overpressure at oil filler, oil in air filter housing, elevated oil consumption

Rubber boost pipes to the intercooler age and burst under driving conditions. On the T5, more frequent than on the T4 due to higher boost pressures. A short-term repair is often possible, but permanent hose replacement is recommended.

Symptoms: Sudden power loss, whistling or hissing noise, check engine light P0299 (turbo underboost)