Skoda Fabia
1.4L three-cylinder unit injector engine, 51 kW (70 hp). Same construction as BNM but lower power output. Same PD-typical weak points. Below 1,500 rpm sluggish; barely suitable for short trips.
80 hp diesel — urban runabout
59 kW in the lightweight Fabia: adequate for city driving and short cross-country runs.
Engine Weaknesses 3
Like all VAG PD-TDI engines, the BWB suffers from camshaft wear due to the mechanical load of the unit injector assemblies. Parts costs for camshaft, bearings and tappets are around €1,170.
Symptoms: Clattering on cold start, increasing valvetrain noise. Power loss and rough idle with advanced wear.
Total engine failure on timing belt snap — the BWB is an interference engine. Strictly follow the manufacturer's service interval (120,000–150,000 km depending on build year).
Symptoms: Sudden stall while driving, loud bang. Engine will not restart.
The camshaft position sensor on the BWB fails sporadically and causes hot-restart issues. Particularly after 30–60 minutes of standstill with a warm engine, restart fails.
Symptoms: Engine starts fine when cold, hot restart after brief standstill fails. Multiple start attempts needed.
Vehicle Weaknesses 8
Certain build years of the Fabia 5J are affected by the Takata airbag recall. The gas generator in the driver's airbag can release metal fragments on deployment.
Moisture enters the tailgate through the licence plate lights and the handle recess. Corrosion spreads under the paint and causes blistering.
Suspension springs fracture from corrosion and material fatigue. Most common at the front axle in the lower coil area.
Ignition coils on petrol engines fail from overheating and insulation faults. Usually individual cylinders affected; all four coils should be replaced together.
Stone chips and road salt cause corrosion on the rear wheel arches. Without treatment, rust spreads under the paint.
The front brake discs wear prematurely in city driving. Disc run-out and vibrations appear earlier than on comparable vehicles.
The electric steering column develops creaking or clicking when turning, especially at low temperatures. The cause is wear in the steering column bearing.
The cabin blower motor starts squeaking or whining from around 80,000 km, especially on lower settings. Dry bearings or debris accumulation are common causes.
Reports & Tests
Older Fabia model years show notable weaknesses at the MOT inspection in brakes and lighting. Oil leaks and corroded exhaust systems increase noticeably with vehicle age.
