Opel Astra
90 hp variant of the small Fiat MultiJet diesel. The timing chain declared maintenance-free by the manufacturer is the biggest weakness and can catastrophically break above 150,000 km. EGR and turbo wastegate are further typical wear items.
Economy as the goal
For those who care more about consumption than driving pleasure – as an estate acceptable for exactly that purpose.
Engine Weaknesses 4
The timing chain, declared maintenance-free, stretches considerably with long oil change intervals. A broken chain means engine damage from valve collision. Total failure documented at 184,000 km.
Symptoms: Rattling on cold start from the timing chain area, easing slightly as it warms up. Sudden engine failure with heavy smoke in total failure cases.
The wastegate actuator on the IHI turbo seizes in the closed position through heat and ageing, leading to excessive boost pressure and limp mode. Turbo overhaul costs approx. 310 EUR.
Symptoms: Vehicle enters limp mode, severely reduced power, engine warning light, occasional whistling or grinding noises from turbo area.
The swirl flaps in the intake manifold coke up from EGR residues and crankcase ventilation. Complete intake manifold with swirl flaps costs approx. 520 EUR plus 250 EUR fitting.
Symptoms: Juddering and power loss especially on cold running, engine warning light with fault code P2279, poor throttle response in part-load range.
The EGR valve carbons up especially on short trips. Failures documented at 81,000–160,000 km. The valve can be cleaned or replaced; replacement part costs approx. 105 EUR.
Symptoms: Hesitation and juddering when cold, intermittent throttle response at part load, engine warning light, power drop.
Vehicle Weaknesses 10
The M32 6-speed manual gearbox has undersized bearings in the gearbox casing. The bearings cannot cope with the factory tolerances long-term, resulting in whining in 5th/6th gear and gear lever vibration on load changes.
The AC condenser sits low in the front end and is heavily exposed to stone damage. Damaged fins lead to refrigerant loss.
The rear brake discs on the Astra H are prone to heavy surface corrosion, especially on vehicles that see little use. Discs often need replacing due to rust rather than wear.
On the Astra H 1.8 petrol engine the oil cooler gaskets fail, creating an oily, sludgy residue in the coolant expansion tank. If ignored, the cooling circuit becomes contaminated.
The electrohydraulic power steering on the Astra H fails intermittently or permanently. Cause: earth fault at the A-pillar to the CIM control unit, or faulty power steering pump. Steering becomes heavy.
Moisture penetrates through the chrome strip at the tailgate lower edge. The sealing is inadequate, leading to zinc bloom and rust under the paint.
The front axle anti-roll bar drop links wear comparatively quickly on the Astra H. Worn drop links cause dull knocking when cornering or over bumps.
Water enters the Astra H estate's boot through porous tailgate seals or leaking roof rail seam sealant. Moisture damage to the carpet and electronics is possible.
Recall (Opel): A contact fault in the steering column module (CIM) causes the horn to fail on Astra H and Zafira B (2004–2010). Affects hundreds of thousands of vehicles.
In the Astra H, plastic clips and trim around the interior mirror, instrument cluster, and centre console loosen. Creaking and rattling at certain RPM levels or road surfaces.
