Land Rover Discovery TD4

The 204DTD timing chain stretches prematurely due to worn plastic guides and degraded lubrication from oil dilution. Chains fitted before 2019 are particularly affected. Chain snap is possible.

Symptoms: Metallic rattling on cold start, engine warning light, power loss, fault codes P0016 or P0341

Incomplete DPF regeneration cycles allow unburnt fuel to drip into the sump. Particularly critical on short trips with the transversely mounted engine — the distance between turbo and DPF is too great for passive regeneration.

Symptoms: Early service warning well before interval, oil level above max mark, fuel smell in oil, increased engine wear

Turbochargers fail due to oil dilution-related lubrication degradation and plastic debris from timing chain guides. A second turbocharger can be destroyed by debris from the first.

Symptoms: Blue or black exhaust smoke, whistling or hissing noise, severe power loss, engine warning light

The 204DTD common rail injectors are damaged by fuel contamination and elevated operating temperatures. Over-fuelling leads to extreme heat buildup and can damage pistons and cylinder liners.

Symptoms: Rough idle, difficult cold starts, excessive black exhaust smoke, increased fuel consumption

The 204DTD EGR valve carbons up with predominantly short-trip and stop-and-go use. A blocked valve increases emissions and adds further load to the pistons.

Symptoms: Excessive soot, power loss at low RPM, engine warning light, rough idle

Coolant leak at the thermostat housing drips onto the piston cooling valve solenoid and destroys it. Causes a false "critically low oil level" warning even when oil level is correct. Part number LR073684.

Symptoms: Yellow engine warning light, false critically low oil level warning, diagnostic code P25A9-00

The DPF regenerates poorly on the transversely mounted Ingenium engine because the DPF sits too far from the turbo and barely reaches the required temperature. Particularly critical in urban driving.

Symptoms: DPF full warning, power drop, increased fuel consumption, difficulty on cold start

The Discovery 5 also suffers from the typical Land Rover air suspension weakness. Air springs become porous after 80,000–120,000 km. The compressor becomes overloaded and early system failures occur.

The InControl Touch Pro system of the Discovery 5 frequently freezes, responds with a delay or shows a black screen. Software updates help; hardware defects on the controller require replacement.

The seal around the tail light unit on the tailgate becomes porous. Water enters the boot area through the rear lights. The Gore-Tex membrane does not keep moisture out permanently.

The InControl system does not fully shut down when the vehicle is left unlocked. Battery is drained overnight. Typical weakness of all JLR models of this generation.

Rear brake discs corrode heavily between uses — typical on vehicles with little city or motorway driving. Corrosion reduces braking performance and causes vibration.

The windscreen seal becomes leaky and allows water to enter the driver or passenger footwell. Control units in the footwell can be damaged. Well-known issue in L462 forums.

The Discovery 5 has an aluminium body that is prone to galvanic corrosion where it contacts steel fasteners. Particularly visible at screw connections and brackets.

The ZF 8HP gearbox shows torque converter shudder or judder in isolated cases, particularly at low temperatures. A transmission fluid flush and software update resolves the issue in most cases.