Fiat Tipo
Modern 3-cylinder turbo engine with innovative FireFly technology, technically complex in design. The integration of EGR into the MultiAir unit makes repairs disproportionately expensive. The mild hybrid system shows early-phase weaknesses with the 12V battery. As a relatively new unit, long-term experience is still limited.
Underpowered
70 hp three-cylinder in a Tipo weighing over 1,300 kg: sluggish when overtaking, loud on the motorway and constantly at the limit. Simply not enough engine for the compact.
Engine Weaknesses 4
On the FireFly 1.0 T3, the EGR is not available as a separate part. If the exhaust gas recirculation solenoid valve fails, the entire MultiAir unit must be replaced. Cost over €2,000.
Symptoms: Engine warning light, power reduction on motorway, check engine message
The small turbocharger of the 1.0 T3 shows noticeable turbo lag on pull-away and is wear-prone with overly long oil change intervals. Reports of whistling noises increase above 100,000 km.
Symptoms: Turbo lag when accelerating from low revs, whistling or hissing noises, power loss
Individual reports describe increased oil consumption and blue exhaust smoke, indicating piston ring or valve stem seal wear. Unusual for a relatively new engine.
Symptoms: Falling oil level between service intervals, blue smoke from the exhaust especially on cold start
The mild hybrid automatically deactivates start-stop and energy recovery as soon as the 12V main battery drops below a threshold. Happens regularly with short-trip use and cold temperatures.
Symptoms: Start-stop not working, hybrid display inactive, charge level indicator at lowest value
Vehicle Weaknesses 14
Recall on the Fiat Tipo (356) for faulty airbag wiring in the steering wheel. Affected model years 2015–2016.
Recall action 2020–2021 on the Fiat Tipo (356) for software faults in the restraint moments.
Recall on the Fiat Tipo (356) for non-conforming airbag charge quantity.
MOT reports show above-average braking efficiency defects for the Fiat Tipo (356). Brake discs rust quickly.
The DDCT dual-clutch gearbox in the Fiat Tipo (356) sometimes shifts erratically and judders on pull-away from rest. Earlier examples more frequently affected.
The UConnect infotainment in the Fiat Tipo (356) stands out for Bluetooth connection drops, DAB reception problems and sporadic system crashes.
The rear torsion beam axle of the Fiat Tipo (356) develops noises with increasing mileage. Rear axle bushes wear.
The AC condenser of the Fiat Tipo (356) is exposed to stone chip damage and can become leaky through corrosion. Replacement costs €400–700.
Exhaust system and underbody components on the Fiat Tipo (356) corrode above-average, already after 5–7 years with short-trip use.
Tie rod ends on the Fiat Tipo (356) wear earlier than the class average and are regularly flagged at MOT.
Vehicles from model years 2016–2017 show more frequent battery failures than the class average. Weak original equipment battery.
Window regulators on the Fiat Tipo (356) can fail due to cable failure or motor failure. Replacement depending on side: €150–350.
Door trims and interior plastics on the Fiat Tipo (356) rattle and creak at normal driving. Typical for this price segment.
Panel gaps on the Fiat Tipo (356) are sometimes uneven from the factory. Doors and bonnets can sit skewed. Not a safety defect but visually annoying.