BMW 316d
Widely used four-cylinder diesel with common-rail injection. Notorious timing chain issue — the chain sits on the gearbox side and elongates with irregular oil changes. Early replacement recommended.
Timing Chain Roulette
Every mile could be the last — the infamous timing chain makes the N47 a permanent nail-biter.
Engine Weaknesses 6
The N47D20 is notorious for its serial timing chain defect. The rear-mounted timing chain stretches and plastic guide rails break. Chain breakage causes total engine failure. Affected: build years 2007–2015.
Symptoms: Scraping or rattling noises on cold start from the rear of the engine. The damage often gives no acoustic warning and occurs suddenly.
The N47 water pump fails prematurely. When it does the engine overheats, causing secondary damage to an already vulnerable engine. Preventive replacement is recommended.
Symptoms: Coolant temperature rises suddenly, coolant loss, engine warning light, in the worst case overheating damage.
The high-pressure pump can wear internally and introduce metal swarf into the fuel system. Rail, pressure sensor, and all injectors are affected — complete system replacement is necessary.
Symptoms: Engine goes into limp mode; will not restart; fault code "rail pressure too low"; in the worst case the engine no longer runs
The EGR valve becomes coked through soot deposits. Contamination accelerates with frequent short-trip use. The valve no longer opens and closes correctly.
Symptoms: Power loss, increased fuel consumption, rough idle, EGR system fault code in memory.
The DPF does not fully regenerate with frequent short-trip use. Soot mass exceeds 45 g, fault code 480A, active regeneration is blocked.
Symptoms: Increased fuel consumption (over 9 L/100 km); rough idling; engine warning light; exhaust smell; DPF fault codes 480A/481A
The dual-mass flywheel wears disproportionately quickly at high mileage with diesel use. BMW revised the pressure plate and clutch disc after 2009/2010 due to a known shudder problem.
Symptoms: Strong vibrations at idle and when pulling away; shudder during gear changes; banging noises at low rpm; no fault code
Vehicle Weaknesses 6
Faulty battery connectors on petrol models 2006–2011 and diesels 2009–2011 can cause complete electrical and engine failure. Recall was issued.
The electromechanical power steering (EPS) can fail sporadically without any fault codes — often due to corroded connectors or an overheated EPS motor. KBA recall for production years 2007–2012.
Rear suspension springs break frequently — a well-known MOT failure point. Especially E91 Touring and older examples from around 100,000 km. Spring seats also rust.
Water ingress through leaking door seals, blocked sunroof drain tubes, or faulty antenna brackets. Battery compartment and footwell can both be affected. Multiple causes.
Control arm bushings and joints wear from around 100,000 km. Aluminium wishbones on the front axle are a typical wear item. Full arm from 200 €, bushings from 10–50 € each.
The acoustic foam in the doors separates from the butyl seal and lets rainwater into the footwell. Damp floor mats and rotting carpet result.